It all depends on your battery bank used with this 36V to 48V conversion. can only be accomplished through installing a 48V motor capable of higher torque, or installing a 48V controller with a higher current limit (amperage). When DC power is discussed, amperage equals torque and voltage equals speed.
How can I make my 36V golf cart go faster?
6 Ways You Can Make a Golf Cart Faster
- Add More Torque to Your Golf Cart.
- Upgrade Your Golf Cart’s Motor.
- Improve the High-Speed Controller of the Cart.
- Add Better Golf Cart Tires.
- Use a Higher Powered Golf Cart Battery.
- Watch the Weight in Your Golf Cart.
Is a 48 volt golf cart faster than a 36 volt?
Basically, a 48V system gives you more “pep in your step” and picks up/speeds up a bit faster than a 36V system. Energy Needed/Amps Drawn- A 48V system draws less amps and provides a little more range with all things being equal (cart/passenger payload weight, motor horsepower, etc).
How many miles will a 36V golf cart go?
A 36 volt golf cart is adequate for 2 to 4 passenger use when you are primarily using it on flat a flat surface. The average drive time or range for a 36 volt DC system is about 30 miles on a full charge. The 48 volt golf cart offers many more advantages in all 2, 4 or 6 passenger models.
Is 30 mph fast for a golf cart?
Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.
Can you put a 36 volt motor in a 48 volt golf cart?
Putting 48V behind a motor that is designed to run 3500rpm (or whatever it may be) at 36V will, in fact, make her run faster. Swap the motor with the battery bank and controller and you will see no speed increase until you reprogram the controller for higher speeds.
Will a 48 volt controller work on a 36 volt golf cart?
if you use a 48V lifepo4 pack then you would wanna use a 36V controller so that the LVC of the controller does not shut it down since the 16S lifepo4 can produce current down to 32V. a 48V controller has a LVC around 40V so it will turn off before you can use all the capacity of the battery.
Can you put 3 12v batteries in a 36V golf cart?
If you have a 36-volt golf cart that runs on six 6-volt batteries, you can replace them with three 12-volt batteries, which often are easier to find.
How long does a 36V golf cart charge last?
Typically, an electric golf cart has between 45 and 90 minutes of full-power run time on a fully charged battery.
Should I keep my golf cart plugged in all the time?
No, it’s not recommended that you leave your golf cart plugged in all the time. Although automatic chargers are designed to prevent over-charging, there is still the risk of the circuit breaker tripping, which would result in damage to your battery’s cells.
Is 20 mph fast for a golf cart?
In order for a golf cart to be street-legal, it needs to meet speeds of 20 miles per hour.
How many volts should a 36V golf cart have?
For example: a 36v battery pack will read 38.2v fully charged. Maximum drop under load should not be more than 6v below 38.2v equal to 32 volts or less.
How many minutes will a 48 volt golf cart run?
A 48V E-Z-GO RXV golf car with an AC motor and new(er) batteries will travel the following distances based on the stated factors: Trojan T-1275+ 12V batteries should run 102 minutes at 56 amps. The max range would be roughly 20.5 miles @ 12 miles/hour, or in golfing terms about 3 rounds or 54 holes.
Should I charge my golf cart after each use?
Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.
What is the fastest electric golf cart?
The fastest electric golf cart that Club Car has on offer is the Villager 2+2 LSV that goes 23 mph. The fastest gasoline Club Car only goes 19 mph. And the fastest electric EZGO is the 2Five that goes 25 mph.
How do you take the governor off a Club Car golf cart?
Look behind the governor to find a small metal rod that’s permanently attached to the club car and stretch your rubber band enough to connect it to that metal rod. Screw the plastic plate back in place. Once the plate is back in place, the governor is disabled.
How can I make my EZ Go golf cart go faster?
One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
Can you put 8 volt batteries in a 36 volt golf cart?
Each battery needs to have the same amp/hr rating, so that they go dead at the same time. Otherwise the smallest battery will limit the other larger ones. So you could use three 8 volt batteries and two six volt batteries to produce 36 volts.
Can you put a 48v battery on a 36v ebike?
Most 36V controllers will support a 48V pack, but the LVC will still be set for a 36V pack, so you’ll need to monitor pack voltage and not let it get too low. You can verify this by opening the controller and checking the caps and fets. If it has 63V main caps it should be fine.
How many batteries do I need for a 36 volt golf cart?
6 batteries
A 36V EZGO cart will have 6 batteries with 3 holes on each battery. Each hole represents a 2 volt cell.
How many volts should a 36 volt charger put out?
The peak charging voltage for Gel batteries is 2.3 to 2.36 volts per cell, and for a 36 volt charger this works out to 41.4 to 42.5 volts, which is lower than a wet or AGM type battery needs for a full charge.
Contents