Most 36V controllers will support a 48V pack, but the LVC will still be set for a 36V pack, so you’ll need to monitor pack voltage and not let it get too low. You can verify this by opening the controller and checking the caps and fets. If it has 63V main caps it should be fine.
Can you use a 36V motor with a 48V battery?
it won’t work unless you regulate the battery to 36v. the controller might be smart enough to regulate, they usually aren’t and will catch fire. if you use a 48v controller on the 36v motor, it will run hot and live short. i once overvolted a 24v currie izip to 36v.
Can I use a 48 volt battery on a 36 volt controller?
usually the 48V conversion on a 36V controller will work but you can change the input power resistors too if needed.
Can I put a bigger battery on my ebike?
Adding more cells to the pack could be a problem with the motor voltage limit but most can handle more. It can also cause charging problems. So if you really want more range and speed you should buy a new high end model E bicycle. With lots of battery progress they cost less and go further.
Can I run a 36V motor on 48V?
yes, you can use a 36V motor with a 48V controller. you can even use a 36V controller and a 48V battery if you wish.
Is 48V better than 36V?
It is pretty simple to understand. A 36V e-bike battery will allow you to draw a lesser critical current, typically around 15 amperes whereas, a 48V e-bike battery will allow more current in the range of 10 – 40 amperes. It means you can go faster with a 48V E-bike battery.
Can you put 48V batteries in a 36V golf cart?
It all depends on your battery bank used with this 36V to 48V conversion. can only be accomplished through installing a 48V motor capable of higher torque, or installing a 48V controller with a higher current limit (amperage). When DC power is discussed, amperage equals torque and voltage equals speed.
Can I use a 36 volt?
Simply stated, a 36V battery system is a set of batteries that operates at 36 volts. The 36-volt setup connects to the loads just like any other battery, but you can only use it for applications designed to operate at 36 volts.
How long does a 36 volt ebike battery last?
For example, a 36v 10ah battery pack with 360 wh of capacity. (36 volts times 10 amp hours equals 360 watt hours). This pack would in theory provide 36 km of range, or 22 miles, from a full 100% charge.
Can I use 48V battery on 60V motor?
If the motor is expecting a particular current at 60V, it should still run at 48V, but the lower voltage will only push about 80% of the optimal current, so the stall torque will be diminished and maximum speed will be diminished.
Will a higher voltage battery make my eBike faster?
A battery that is at a higher state of charge has a higher voltage. The speed of a DC motor (like the one in your e-bike) is entirely voltage dependent. So higher voltages = higher speeds. By keeping your battery at a higher state of charge, you’ll inherently travel faster.
How do I upgrade my bike to electric?
There are a number of ways to electrify your existing bike for assistance up those hills: you can fit a powered wheel, either front or rear; you can attach a drive unit to the bottom bracket; you can fit a motor above the rear wheel and drive it via friction; or, most sneakily, you can conceal a motor in the seatpost.
Can you use 48V battery with 350W motor?
Re: 48v battery on 350W ezee motor
Depends on how many watts your lyen controller is going to allow into your 350 motor. I’d say 20 amps would be about the most you’d want to put on it. 1000w. Bear in mind, that doesn’t mean you will pull 1000w, 20 mph travel should still take the usual 400-500w unless climbing hills.
Can 36V motor run on 48V golf cart?
Putting 48V behind a motor that is designed to run 3500rpm (or whatever it may be) at 36V will, in fact, make her run faster. Swap the motor with the battery bank and controller and you will see no speed increase until you reprogram the controller for higher speeds.
Can I use a 48V battery on a 24V motor?
Re: Advice: 24V controller with 48V battery
As is,, it may well run fine on 48v, but have a very low setting on it’s low voltage cutoff. As long as you are not relying on that cutoff in place of a bms on the battery,, I’d just run it as is.
How can I reduce 48V to 36v?
Simplest way to reduce voltage from ~48v to ~36v
- Input is 39-55v, output needs to be between 29-44v.
- Current on the wire is 80-120ma.
- It would be great it if this could be done proportionally, or with a constant voltage drop, instead of just regulating to a set output.
How fast does a 36v eBike go?
Is It Legal To Travel At 15 – 20mph On My 36v Electric Bicycle? Yes, as long as the bicycle does not exceed the speed limits of the roads you are cycling on, you are perfectly in your legal right to ride at the top speed that your 36v bike can go.
Can you put a 52 volt battery on a 48 volt eBike?
As long as you are using a Juiced Bike with an LCD display, the 52V battery can be used. The 52V battery pack is designed to be interchangeable with that of the 48V bikes that use an LCD display (CrossCurrent S and RipCurrent S). These bikes were actually initially designed to use the 52V system.
Is 48V faster than 36V?
Basically, a 48V system gives you more “pep in your step” and picks up/speeds up a bit faster than a 36V system. Energy Needed/Amps Drawn- A 48V system draws less amps and provides a little more range with all things being equal (cart/passenger payload weight, motor horsepower, etc).
How can I make my 36 volt golf cart faster?
6 Ways You Can Make a Golf Cart Faster
- Add More Torque to Your Golf Cart.
- Upgrade Your Golf Cart’s Motor.
- Improve the High-Speed Controller of the Cart.
- Add Better Golf Cart Tires.
- Use a Higher Powered Golf Cart Battery.
- Watch the Weight in Your Golf Cart.
How can I get more power out of my 36 volt golf cart?
Change the Motor Achieving higher speeds can be as simple as increasing the voltage of the battery from the standard 36-volt to a 42-volt charge. The increased voltage to the motor will give you more revs per minute (RPM), resulting in speeds up to 20mph.
Contents